Working In The Cold

Here are a few tips that the Minnesota-based CPT crew has picked that will help you stay warm and productive when mercury starts to plummet.

cold weather

1 / 13

Cold weather construction

Working construction in a northern climate during the long dark winter months can be a challenge. CPT is based in Minnesota, and we've learned a few things about construction work in freezing cold, ice and snow. Here are some great tips to help you rise to the chilly occasion.

mittens

2 / 13

Have a variety of gloves on hand

Different tasks require different gloves. Tight, thin gloves are perfect for delicate tasks like grabbing hold of small screws or twisting wires. Keep thicker gloves or mittens handy for moving equipment or hauling cold, wet material. Oversize gloves or choppers like these will fit right over your form-fitting gloves, so you can keep your hands warm all day but slip the outer pair off for short periods to do detail work.

mud protection

3 / 13

Keep your pants dry and mud free

A pair of leg gaiters is a must-have shield in every proper suit of arctic armor. Leg gaiters keep the outside of your pants dry when you trudge through deep snow. They also keep wind and snow from creeping up the inside of your pants. Leg gaiters are also useful in muddy conditions because they protect your pants from your mucky boots, especially when you climb up and down ladders. Plus, they’re easy to take off at the end of the day to avoid tracking all that accumulated muck into your vehicle or house. You can get a pair for as little as 10 bucks online.

scaffolding

4 / 13

Ice-free planks

It’s always a good idea to flip planks on their side or upside down when you leave the job site for the night. That will prevent ice from forming on the walking surface and keep the crew safer the next day. And set planks and ladders on their side when storing them on the ground.

ice

5 / 13

Prevent slipping

The ground will get extra slippery in high-traffic areas and where water drips off the roof. Sprinkling sand on the icy spots is a great way to prevent a fall. Keep a 5-gallon bucket of dry sand on hand. It’s also wise to spread sand on a slippery plank if you’re working when it’s snowing.

Layers

6 / 13

Dress in layers

This might be “duh” advice, but it’s worth a mention because it’s probably the most important rule for working in the cold. Weather conditions change constantly during a workday. It might feel 20 degrees warmer on the sunny side of the house or 20 degrees colder when you’re exposed to a brisk wind. In order to remain comfortable, you need to be able to make wardrobe adjustments. Wearing just one super-insulated layer will inevitably cause you to sweat when things heat up. And when things cool back down, you’ll be wet and shivering like a chilly Chihuahua. This handsome devil is wearing, pants, long-sleeve tee-shirt, flannel shirt, bibs, and a light jacket...toasty!

Boot Dryers

7 / 13

Dry feet are happy feet

Sweat, rain and snow will cause the inside of your boots to get wet—it’s pretty much unavoidable. It’s imperative you dry out wet boots overnight. If you go to work the next day with damp feet, you’ll be ending work early because of cold feet. Boot dryers like this are worth their weight in gold. They dry boots evenly and thoroughly but don’t over-dry them, which can cause the liners to get crusty and reduce their life. They cost less than $20 online and at sporting goods stores and some department stores. Keeping a pair of dry socks on hand is also smart.

padlock tips

8 / 13

Defrost a padlock

Sleet and freezing rain can prevent a padlock from opening. Loosen up a frozen lock by warming a can of silicone or light lubricant and spraying it into the keyhole and the areas around the shackles. Note to naysayers: Some say that liquid lubricants are bad for locks, but we all have sprayed our padlocks dozens of times, and they have continued to work trouble-free for years.

Dashboard

9 / 13

Warm up stuff on your dashboard

When working at a job site with no source of heat other than your truck engine, use your dashboard to dry out gloves, thaw caulking, warm cordless tool batteries, keep your lunch from freezing—you get the idea. Also, on sunny days, try to park the front of your vehicle toward the south. The sun will keep your dash fairly warm even in frigid temps without the motor running.

Neck Gaiters

10 / 13

Neck gaiters are a must

There’s no better accessory to keep your neck warm than a neck gaiter. Buy one long enough that you can pull it all the way up to your eyeballs for those particularly windy or brutally cold days. Forget or lose your gaiter? Many convenience store/gas stations sell cheap stocking caps. Cut a hole in the top and you’ve got yourself a neck gaiter.

Ladder Tricks

11 / 13

Prevent ladder disasters

When your feet slip out from under you, you’ll probably bruise your bum and look around hoping nobody saw you. When the feet of a ladder slip out, you’re going to hurt more than your pride. Keep ladders upright on icy ground by digging holes for the feet and flipping the feet back so the spurs poke into the ground.

Sawhorse

12 / 13

Support sawhorse legs

It’s true that frozen ground makes a nice, stable surface for sawhorses. But sawhorse legs can sink into the thawed ground when the temps rise, which will make them unstable. Also, if the legs do sink and the ground refreezes, you’re going to need a jackhammer to free them. Place chunks of wood under the legs to keep them on terra firma.

Contribute

13 / 13

We'd Love to Hear From You

Do you have a jobsite or tool tip that makes your work-life easier, safer, or just more fun?  Why not share it with your construction comrades? Plus, you can show off your professional prowess to your family and friends.

Click the image below to send us your Pro Tips! Please include an image if you can. We will contact you if we run your submission on the site.